文章摘要信息

中国电机工程学报 2009, 29(17) 56-62 DOI: ISSN: 0258-8013 CN: 11-2107/TM

本期目录 | 下期目录 | 过刊浏览 | 高级检索 [打印本页] [关闭]

工程热物理

	扩展功能

	本文信息
	Supporting info
	PDF(405KB)
	[HTML全文]
	参考文献[PDF]
	参考文献
	服务与反馈
	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	引用本文
	Email Alert
	文章反馈
	浏览反馈信息
	本文关键词相关文章
	模拟烟气
	汞
	改性
	氢氧化钙
	吸附
	脱除
	本文作者相关文章
	黄治军
	段钰锋
	王运军
	孟素丽
	焦永刚
	PubMed
	Article by Huang,Y.J
	Article by Duan,Y.F
	Article by Yu,Y.J
	Article by Meng,S.L
	Article by Qiao,Y.G

改性氢氧化钙吸附脱除模拟烟气中汞的试验研究

黄治军，段钰锋，王运军，孟素丽，焦永刚

东南大学能源与环境学院

摘要：对氢氧化钙进行了2种改性，并在小型模拟燃煤烟气Hg吸附和形态转化试验台上研究其对模拟烟气中Hg的脱除效果。结果表明：Ca(OH)2对单质汞的吸附主要是物理吸附，低温有利于汞的吸附；SO2和HCl均可以促进Ca(OH)2对汞的吸附，HCl对汞的氧化能力强于SO2，促进作用更明显；KMnO4改性后的Ca(OH)2在基本气体中可以将大部分的Hg0氧化为Hg2+，在有SO2或HCl存在的条件下可以脱除烟气中50%以上的Hg，改性后的吸附以化学吸附为主；利用AgNO3改性后的Ca(OH)2对汞的吸附能力极大增强，脱除效率可达90%，主要原因是银汞齐反应的发生，该法可望实现吸附剂的再生和Hg的回收利用，具有实际应用的前景。

关键词：模拟烟气汞改性氢氧化钙吸附脱除

Experimental Investigation on Absorption of Hg in Simulated Fuel Gas by Modified Ca(OH)2

HUANG Zhi-jun, DUAN Yu-feng, WANG Yun-jun, MENG Su-li, JIAO Yong-gang

School of Energy and Environment, Southeast University

Abstract: Two kinds of modified adsorbents based on Ca(OH)2 were experimentally prepared. Then their adsorption capacities to mercury in simulated flue gas were investigated on a beach-scale fixed bed set-up. The results show that the adsorption of Ca(OH)2 to Hg0 is mainly controlled by physical mechanisms, and low temperature is beneficial to it. SO2 and HCl both promote the adsorption ability of Ca(OH)2. The promotion of HCl is more significant than that of SO2 due to it’s stronger oxidation ability to Hg0. KMnO4 modified Ca(OH)2 can oxidize large amount of Hg0 into Hg2+ in the base line flue gas system and adsorb more than 50% of the total Hg at the presence of SO2 or HCl, which is mainly controlled by chemiadsorption mechanisms. When modified by AgNO3, an amalgamated silver reaction may occur on the surface of Ca(OH)2 so that a 90% mercury removal rate then reaches. It can not only have stronger adsorption ability to flue gas mercury, but also can be potentially regenerated and make mercury reclaimed.

Keywords: simulated flue gas mercury modification calcium hydroxide adsorption removal

收稿日期 2008-09-03 修回日期 网络版发布日期 2009-06-18

DOI:

基金项目:

国家重点基础研究发展计划项目(973项目)(2006CB200304)。

通讯作者: 黄治军

作者简介:

作者Email:

参考文献：

本刊中的类似文章

1．高洪亮周劲松骆仲泱岑可法.改性活性炭对模拟燃煤烟气中汞吸附的实验研究[J]. 中国电机工程学报, 2007,27(8): 26-30

2．陈进生袁东星李权龙郑剑铭朱燕群华晓宇何胜周劲松.燃煤烟气净化设施对汞排放特性的影响[J]. 中国电机工程学报, 2008,28(2): 72-76