|
|
中国电机工程学报 2009, 29(5) 21-26 DOI:
ISSN: 0258-8013 CN: 11-2107/TM |
|
|
|
|
本期目录 |
下期目录 |
过刊浏览 |
高级检索
[打印本页]
[关闭] |
|
| 热能工程 |
|
|
氨法脱硫过程烟气中细颗粒物的变化特性 |
|
|
颜金培，杨林军，鲍静静，蒋振华，黄永刚，沈湘林 |
|
|
东南大学能源与环境学院 |
|
|
摘要：
采用电称低压冲击器(electrical low pressure impactor，ELPI)对氨法脱硫前后的细颗粒进行测量，获得烟气中细颗粒的数浓度和粒径分布特性，分析了氨法脱硫过程细颗粒的生成机制及洗涤塔对细颗粒的捕集特性。结果表明，氨法脱硫后细颗粒的数浓度明显增加，在SO2浓度为1 767 mg/m3和氨水浓度为5%，平均粒径由洗涤前的0.07 mm增大到0.09 mm；常规洗涤对细颗粒的脱除效率很低且几乎不受液气比影响；而氨水脱硫时，洗涤塔出口的颗粒数浓度随液气比的增大而提高，特别是氨水浓度较高的情况；氨水浓度为10%，液气比从2 L/m3增加到5 L/m3，颗粒数浓度增加了10%；此外，随氨水浓度和烟气中SO2浓度的增大，洗涤后颗粒的数浓度增加。 |
|
|
关键词：
氨法脱硫
细颗粒
粒径分布
洗涤
|
|
|
Impact Property on Fine Particles From Coal Combustion in Ammonia Flue Gas Desulfurization Process |
|
|
YAN Jin-pei, YANG Lin-jun, BAO Jing-jing, JIANG Zhen-hua, HUANG Yong-gang, SHEN Xiang-lin |
|
|
School of Energy and Environment, Southeast University |
|
|
Abstract:
Fine particles before and after wet flue gas desulfurization with ammonia were measured by electrical low pressure impactor (ELPI). Number concentrations and size distributions characteristics of fine particles in flue gas were obtained. The capture effects of fine particles using scrubber and aerosol formation mechanisms in ammonia desulfurization process were investigated. The results show that particle number concentration has an obvious increase after ammonia desulfurization and the mean size increase from 0.07mm before scrubbing to 0.09mm after ammonia desulfurization. The removal efficiency of submicron particles is extremely low using wet scrubber with plain water and independent on the ratio of liquid to gas. But particle number concentration in the outlet of scrubber increases with the ratio of liquid of gas with ammonia desulfurization, especially for higher concentration of ammonia. With the ratio of liquid to gas improved from 2L/m3 to 5L/m3 and ammonia concentration of 10%, the particle number concentration can be improved more than 10%. Moreover, particle number concentration after ammonia desulfurization increases with the concentration of SO2 and ammonia. |
|
|
Keywords:
ammonia desulfurization
fine particles
size distribution
scrubbing
|
|
|
收稿日期 2008-06-23 修回日期 2008-07-02 网络版发布日期 2009-03-10 |
|
|
DOI: |
|
|
基金项目:
国家自然科学基金项目(20576020)；国家重点基础研究发展规划基金项目(2002CB211604)。 |
|
|
通讯作者: 颜金培 |
|
|
作者简介: |
|
作者Email: |
|
|
| 参考文献： |
|
| 本刊中的类似文章 |
| 1．赵兵 姚刚 杨林军 陈厚涛 沈湘林.燃煤细颗粒和颗粒团动力学特性的比较[J]. 中国电机工程学报, 2007,27(8): 1-4 |
| 2．张小锋 姚强 宋蔷 李水清.燃烧中铅元素排放特性的实验研究[J]. 中国电机工程学报, 2007,27(32): 18-23 |
| 3．颜金培 杨林军 凡凤仙 沈湘林.基于分形理论的水汽在燃煤细颗粒表面异质核化数值研究[J]. 中国电机工程学报, 2009,29(11): 50-56 |
| 4．鲍静静 杨林军 颜金培 黄永刚 蒋振华 沈湘林.应用蒸汽相变协同脱除细颗粒和湿法脱硫的实验研究[J]. 中国电机工程学报, 2009,29(2): 13-19 |
| 5．陈厚涛 赵兵 徐进 沈湘林.燃煤飞灰超细颗粒物声波团聚清除的实验研究[J]. 中国电机工程学报, 2007,27(35): 28-32 |
| 6．张小锋 姚强 宋蔷 李水清.燃烧中吸附剂捕集铅的实验研究[J]. 中国电机工程学报, 2008,28(2): 61-65 |
| 7．王珲 宋蔷 姚强 陈昌和.电厂湿法脱硫系统对烟气中细颗粒物脱除作用的实验研究[J]. 中国电机工程学报, 2008,28(5): 1-7 |
| 8．赵永志 郑津洋.宽粒径分布流化床的微观尺度模拟与分析[J]. 中国电机工程学报, 2007,27(35): 55-61 |
| 9．吴晅 李铁 蔡杰 袁竹林.水煤浆气化炉洗涤室内气体穿越液池过程颗粒分布的数值模拟[J]. 中国电机工程学报, 2008,28(20): 15-21 |
| 10．颜金培 杨林军 张霞 孙露娟 张宇 沈湘林.凝结洗涤塔脱除燃煤超细颗粒实验研究[J]. 中国电机工程学报, 2008,28(23): 8-13 |
| 11．贾勇 钟秦 杜冬冬 韦飞.填料塔氨法脱硫模型研究[J]. 中国电机工程学报, 2009,29(14): 52-57 |
| 12．李海龙 张军营 赵永椿 杨艳 郑楚光.燃煤细颗粒固液团聚实验研究[J]. 中国电机工程学报, 2009,29(29): 62-66 |
|
| Copyright by 中国电机工程学报 |
